您好,歡迎光臨萊州中科聚峰機械有限公司官方網站! 鄭重聲明 進入官網

如何操作中科自上料水泥攪拌車?

來源:http://www.pingqxw.com/ 日期:2020-06-12 發布人:zhongke
  1.檢查中科自上料水泥攪拌車是否順暢,四條腿是否支撐牢固;
  1. Check whether the concrete mixer of Zhongke is smooth and whether the four legs are firmly supported;
  2. 機器空載運行是否正常;
  2. Whether the machine operates normally without load;
  3.將泵注滿水并測試一次;
  3. Fill the pump with water and test once;
  4. 檢查電器接地情況。
  4. Check the electrical grounding.
  二是自上料水泥攪拌車的使用要求
  Second, the use requirements of concrete mixer
水泥自動攪拌車
  1.每次添加的攪拌料不得超過規定的值,料斗只有在攪拌出后才能提起進料;
  1. The mixing material added each time shall not exceed the specified value, and the hopper can only lift the feed after mixing out;
  2.攪拌缸反轉時,切勿拉操作手柄;
  2. When the mixing cylinder is reversed, do not pull the operating handle;
  3.為減少粘罐現象,進料斗的順序為石頭-水泥-沙子或沙子-水泥-石頭;
  3. In order to reduce tank sticking, the order of feeding hopper is stone cement sand or sand cement stone;
  4.攪拌桶進料時及時加水,縮短攪拌時間,減少粉塵飛揚;
  4. Add water in time when feeding the mixing barrel to shorten the mixing time and reduce dust flying;
  5.料斗抬起后,任何人不得停留或從料斗下通過;當必須在料斗下進行維修時,應先用安全鏈將料斗緊固,才能進行維修。
  5. After the hopper is lifted, no one is allowed to stay or pass under the hopper; when maintenance must be carried out under the hopper, the hopper shall be fastened with safety chain before maintenance.
  6.嚴禁非工作人員隨意拉動控制手柄;機器不運轉時,必須用安全鉤固定;
  6. It is strictly prohibited for non staff to pull the control handle at will; when the machine is not running, it must be fixed with a safety hook;
  7、注意電氣安全,經常檢查地面是否良好,防止電機受潮,防止損壞電氣元件、電線;
  7. Pay attention to electrical safety, check whether the ground is in good condition, prevent the motor from getting damp, and prevent damage to electrical components and wires;
  8.當斷電時,可以用曲柄搖動減速帶盤,將物料從氣缸中取出;
  8. When the power is cut off, the crank can be used to shake the reduction belt plate to take out the material from the cylinder;
  9.當機器停放時,必須放下四個支撐腳來支撐機器的重量;
  9. When the machine is parked, four supporting feet must be put down to support the weight of the machine;
  3自上料水泥攪拌車的完成要求
  3 requirements for completion of concrete mixer
  1.停機前,應加入一定量的石子和水,攪拌5-10分鐘后釋放,以消除缸內堆積,避免粘罐;
  1. Before shutdown, a certain amount of stones and water shall be added and released after mixing for 5-10 minutes to eliminate accumulation in the cylinder and avoid tank sticking;
  2. 清潔有灰堆積和粘著的混凝土;
  2. Clean the concrete with ash accumulation and adhesion;
  3.將料斗置于輸送位置,懸掛安全鏈;所述控制手柄由安全鉤固定;
  3. Place the hopper in the conveying position and hang the safety chain; the control handle is fixed by the safety hook;
  4. 切斷電源,鎖好電箱;
  4. Cut off the power supply and lock the electric box;
  5. 在嚴寒季節,將供水系統的水全部排干;
  5. In the severe cold season, drain all the water in the water supply system;
  6. 向每個潤滑點添加必要的潤滑油。
  6. Add necessary lubricating oil to each lubricating point.
  以上是水泥自動攪拌車廠家小編為大家介紹的相關內容,想要了解更多內容,歡迎訪問網站:http://www.pingqxw.com
  The above is the relevant content introduced to you by China Science and technology concrete mixer manufacturer. To learn more, please visit the website: http://www.pingqxw.com

上一篇:水泥自動攪拌車夜間行車操作應該注意什么?
下一篇:自上料水泥攪拌車常用的三種類型的歷史

Japanesemature高清无码