您好,歡迎光臨萊州中科聚峰機械有限公司官方網站! 鄭重聲明 進入官網

水泥自動攪拌車罐子不轉了還能修理嗎?

來源:http://www.pingqxw.com/ 日期:2020-06-29 發布人:zhongke
一、檢查一下液壓油是否漏光了(管子壞了換管子,密封件壞了換密封件)!
1、 Check whether the hydraulic oil leaks completely (change the pipe if the pipe is broken, change the seal if the seal is broken)!
二、檢查一下散熱器風扇在轉沒有,液壓油乳化變白沒有,液壓油溫度超過90度,液壓系統就沒有壓力,罐子就不轉了!(這種情況不要著急,用水冷卻一下液壓泵,液壓馬達,液壓油溫度下來,罐子就可以轉動了。把料放出來,趕緊修理散熱器或更換液壓油!)
2、 Check whether the radiator fan is running, whether the hydraulic oil emulsion turns white, if the hydraulic oil temperature exceeds 90 degrees, the hydraulic system will have no pressure, and the tank will not rotate! (in this case, do not worry, cool the hydraulic pump and hydraulic motor with water, and the tank will be able to rotate when the hydraulic oil temperature drops. Put the material out and repair the radiator or change the hydraulic oil quickly!)
三、運輸途中沒有注意,罐子停了!混凝土塌住了,罐子翻不過去!(感覺有壓力能轉一點就可能是這種情況)
3、 Didn't pay attention to the transportation, the tank stopped! The concrete collapsed, and the tank couldn't turn over! (this may be the case if you feel pressure and can turn a little.)
四、發動機故障(不可能哦,轟隆隆響起在!!)
4、 Engine failure (impossible, boom in the ring!)
五、傳動軸十字節損壞,斷了(a斷了立即更換一根傳動軸;b傳動軸好的);
5、 The cross section of transmission shaft is damaged and broken (a is broken, replace a transmission shaft immediately; B drive shaft is good);
水泥自上料攪拌車
六、液壓泵損壞了(情況復雜一點,內瀉嚴重,其他損壞);
6、 The hydraulic pump is damaged (the situation is more complicated, the internal leakage is serious, and other damages);
以上六種情況出現,且混凝土沒有凝結,液壓馬達、減速機沒有故障,可以使用應急裝置,用另一輛攪拌車的液壓泵帶動液壓馬達轉動罐子,將混凝土放出,再檢修!
If the above six cases occur, and the concrete does not condense, and the hydraulic motor and reducer have no fault, you can use the emergency device, use the hydraulic pump of another mixer to drive the hydraulic motor to rotate the tank, release the concrete, and then overhaul!
七、液壓馬達損壞了!
7、 The hydraulic motor is damaged!
八、減速機壞了!!
8、 The reducer is broken!!
七、八兩種情況出現,不能使用應急裝置!可以將罐體上的檢查蓋打開將混凝土放出。
7、 In case of two situations, the emergency device can not be used! The inspection cover on the tank can be opened to release the concrete.
⊙可以用塔機、卷揚機將罐體檢查蓋旋轉到下方,將混凝土放出;
⊙ tower crane and winch can be used to rotate the tank inspection cover to the lower part to release the concrete;
⊙罐子卡住了旋轉不動怎么辦?
⊙ what to do if the jar is stuck and can't rotate?
⊙可以在罐體側下方用氣割開一個50厘米見方的孔(注意避開罐里的螺旋葉片,割下的罐壁一定保留,修復起來迅速、方便而且美觀),將混凝土放出。
⊙ a 50cm square hole can be cut under the side of the tank with gas (pay attention to avoid the spiral blade in the tank, keep the cut tank wall, and repair it quickly, conveniently and aesthetically), and discharge the concrete.
本文由水泥自上料攪拌車提供技術支持,更多的詳細精彩內容請點擊http://www.pingqxw.com我們的網站,我們將會全心全意為您提供滿意的服務
This paper is supported by Zhongke self feeding mixer. For more details, please click http://www.pingqxw.com Our website, we will wholeheartedly provide you with satisfactory service

上一篇:自動攪拌車在進行剎車時應該注意什么?
下一篇:小型水泥自動攪拌車的特點

Japanesemature高清无码